Chevrolet Impala Recalls: Every NHTSA Recall by Model Year

Component: Service brakes

Impala model years: 2018–2019 · about 210,628 vehicles in the whole campaign

The problem: General Motors LLC (GM) is recalling certain 2018-2019 Chevrolet Equinox, Impala, Cruze, Volt and Bolt EV vehicles, GMC Terrain vehicles, Buick Lacrosse and Regal vehicles, Cadillac XTS and XTS Professional vehicles and 2018 Chevrolet Malibu vehicles. The rear brake caliper pistons may have an insufficient coating causing gas pockets to form, potentially reducing rear brake performance.

The risk: A reduction of braking performance can increase the risk of a crash.

The fix: GM will notify owners, and dealers will bleed the vehicle's brake system, free of charge. The recall began October 11, 2018. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 18279.

Component: Air bags (sensor, occupant classification)

Impala model years: 2009–2010 · about 289,254 vehicles in the whole campaign

The problem: General Motors LLC (GM) is recalling certain model year 2009-2010 Chevrolet Impala vehicles manufactured April 25, 2008 through February 16, 2010. The front passenger seat frame may contact and damage the wires of the passenger presence sensor module.

The risk: If the wires are damaged, the passenger presence sensory system may fail to recognize that the passenger seat is occupied, disabling the air bag. Damage may also cause the air bag fuse to short resulting in a loss of all air bags and seat belt pretensions. Both conditions increase the risk of injury during a crash.

The fix: GM will notify owners, and dealers will double wrap the wires with anti-abrasion tape and replace damaged wires as necessary, free of charge. The recall began on August 1, 2016. Owners may contact Chevrolet customer service at 1-800-521-7300. GM's recall campaign number is 36110.

Component: Engine & cooling (exhaust system, manifold/header/muffler/tail pipe)

Impala model years: 2000–2004 · about 1,003,556 vehicles in the whole campaign

The problem: General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.

The risk: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.

The fix: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engine’s front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.

Component: Air bags

Impala model years: 2014–2015 · about 5,493 vehicles in the whole campaign

The problem: General Motors LLC (GM) is recalling certain model year 2014-2015 Chevrolet Impala vehicles manufactured April 15, 2013, to June 19, 2015, equipped with front vented-heated passenger seats. Accordingly, the Automatic Occupant Sensing (AOS) system may fail to suppress the front passenger air bag if a child seat is in the front passenger seat. These vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 208, "Occupant Crash Protection."

The risk: If the front passenger air bag deploys with a child seat in the front passenger seat, it increases the risk of injury to the child.

The fix: GM will notify owners, and dealers will correct the calibration-learning error by preconditioning the empty seat, and also resetting the ECU to a seat zero-value, free of charge. The recall began on August 25, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15400.

Component: Parking brake

Impala model years: 2014 · about 126 vehicles in the whole campaign

The problem: General Motors LLC (GM) is recalling certain model year 2014 Chevrolet Impala vehicles manufactured March 22, 2013, to May 22, 2014. In the affected vehicles, the electronic parking brake piston actuation arm may not fully retract causing the brake pads to stay partially engaged. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Systems (FMVSS) No. 135 "Light Vehicle Brake Systems."

The risk: Brake pads that remain partially engaged with the rotors may cause excessive brake heat that may result in a fire.

The fix: GM has notified owners, and dealers will reprogram the electronic parking brake control module with new software, free of charge. The recall began on May 6, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15259. Note: The vehicles covered by this campaign were previously remedied incorrectly under campaigns 14V541 or 15V085.

Component: Engine & cooling (engine)

Impala model years: 2004 · about 330,742 vehicles in the whole campaign

The problem: General Motors LLC (GM) notified the agency on April 2, 2015, that they are is recalling certain model year 2004 Buick Regal vehicles manufactured April 9, 2003, to June 1, 2003, 2004 Chevrolet Impala vehicles manufactured April 8, 2003, to June 23, 2003, and 2004 Chevrolet Monte Carlo vehicles manufactured April 7, 2003, to June 23, 2003. On May 18, 2015, GM expanded the recall to cover an additional 49,751 2004 Pontiac Grand Prix vehicles manufactured January 6, 2003, to June 25, 2004. In the affected vehicles, the valve cover gasket may leak.

The risk: The leaking engine oil can drip onto the hot surface of the exhaust manifold, increasing the risk of a fire.

The fix: GM will notify owners, and dealers will remove the plastic cover and plastic oil fill tube extension and replace the front valve cover and gasket. These repairs will be done free of charge. The recall began on April 24, 2015. Owners may contact Buick customer service at 1-800-521-7300, Pontiac customer service at 1-800-762-2737 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14574.

Component: Parking brake

Impala model years: 2014 · about 3,660 vehicles in the whole campaign

The problem: General Motors LLC (GM) is recalling certain model year 2014 Chevrolet Impala vehicles manufactured November 15, 2012, to May 30, 2014. In the affected vehicles, the electronic parking brake piston actuation arm may not fully retract causing the brake pads to stay partially engaged. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Systems (FMVSS) No. 135 "Light Vehicle Brake Systems."

The risk: Brake pads that remain partially engaged with the rotors may cause excessive brake heat that may result in a fire.

The fix: GM will notify owners, and dealers will reprogram the electronic parking brake control module with new software, free of charge. The recall began March 5, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 (Chevrolet). GM's number for this recall is 15100. Note: This recall covers a limited population of vehicles that were remedied incorrectly under recall 14V-541.

Component: Electrical system

Impala model years: 2014 · about 106,307 vehicles in the whole campaign

The problem: General Motors LLC (GM) is recalling certain model year 2013-2014 Cadillac CTS, Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, GMC Yukon, and Yukon XL, and 2014 Buick Enclave, Chevrolet Express, Impala, Silverado HD, Traverse, GMC Acadia, Savana, and Sierra HD vehicles. In the affected vehicles, the chassis electronic module may be internally contaminated, resulting in an electrical short.

The risk: If the module experiences an electrical short, the vehicle could stall, increasing the risk of a crash.

The fix: GM will notify owners, and dealers will replace the chassis electronic module, free of charge. The recall began on December 26, 2014. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-458-006 (Cadillac), 1-800-222-1020 (Chevrolet), and 1-800-462-8782 (GMC). GM’s number for this recall is 14515.

Component: Parking brake

Impala model years: 2014–2015 · about 205,309 vehicles in the whole campaign

The problem: General Motors LLC (GM) is recalling certain model year 2013-2015 Cadillac XTS vehicles manufactured February 14, 2012, to August 22, 2014, and 2014-2015 Chevrolet Impala vehicles manufactured November 5, 2012, to September 2, 2014. In the affected vehicles, the electronic parking brake piston actuation arm may not fully retract causing the brake pads to stay partially engaged.

The risk: Brake pads that remain partially engaged with the rotors may cause excessive brake heat that may result in a fire.

The fix: GM will notify owners, and dealers will update the electronic parking brake software, free of charge. The recall began on October 28, 2014. Owners may contact Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is 14471.

Component: Air bags (frontal, sensor/control module-inactive)

Impala model years: 2014 · about 5 vehicles in the whole campaign

The problem: General Motors LLC (GM) is recalling certain model year 2013-2014 Cadillac XTS vehicles manufactured April 11, 2013, to June 27, 2013, and 2014 Chevrolet Impala vehicles manufactured May 13, 2013, to November 5, 2013. The affected vehicles may have left the factory with the sensing and diagnostic module (SDM) set to "manufacturing mode."

The risk: In manufacturing mode, the vehicle's air bags will not deploy in the event of a crash, increasing the risk of occupant injury.

The fix: GM will notify owners, and dealers are to reprogram the SDM to the correct mode, free of charge. The recall is expected to begin in September 2014. Owners may contact Cadillac customer service at 1-800-458-8006 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14532.

Component: Structure

Impala model years: 2014–2015 · about 14,940 vehicles in the whole campaign

The problem: General Motors LLC (GM) is recalling certain model year 2014-2015 Chevrolet Impala vehicles manufactured May 7, 2014, to July 28, 2014. In the event of an accident, the center storage console may not stay latched. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard No. 201, "Occupant Protection In Interior Impact."

The risk: The storage compartment door may not remain closed in the event of a crash, increasing the risk of occupant injury.

The fix: Parts to remedy this condition are not currently available. GM will send owners an interim notification in early October 2014, and will send a second letter when parts are available. At that time dealers will inspect, and if necessary, replace the console storage compartment door inertia latch, free of charge. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14476.

Component: Steering (electric power assist system)

Impala model years: 2014 · about 57,242 vehicles in the whole campaign

The problem: General Motors LLC (GM) is recalling certain model year 2014 Chevrolet Impala vehicles manufactured November 5, 2012, to December 20, 2013. Due to a poor electrical ground connection to the Power Steering Control Module (PSCM), the affected vehicles may have a loss of power steering assist during start up or while driving.

The risk: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.

The fix: GM will notify owners, and dealers will clean paint from behind the ground stud nut and update the PSCM software, free of charge. Owners may contact Chevrolet customer service at 1-800-222-1020. The recall began on August 21, 2014. GM's number for this recall is 14330.

Component: Electrical system (ignition)

Impala model years: 2000–2005 · about 5,877,718 vehicles in the whole campaign

The problem: This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.

The risk: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

The fix: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.

Component: Steering

Impala model years: 2014 · about 106 vehicles in the whole campaign

The problem: General Motors LLC (GM) is recalling certain model year 2014 Buick Regal, Cadillac XTS, Chevrolet Camaro and Chevrolet Impala vehicles. Improperly torqued fasteners may cause the steering intermediate shaft and the steering gear and/or the lower control arm and the lower ball joint to separate.

The risk: If any of the components separate, the vehicle may have a loss of steering, increasing the risk of a crash.

The fix: GM began to notify owners on June 27, 2014, and dealers will inspect the fasteners for correct torque, correcting them as necessary, free of charge. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-458-8006 (Cadillac) or 1-800-222-1020 (Chevrolet). GM's number for this recall is 14378.

Component: Electrical system (ignition)

Impala model years: 2006–2014 · about 3,141,731 vehicles in the whole campaign

The problem: This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) is recalling certain model year 2005-2009 Buick LaCrosse, 2006-2011 Buick Lucerne, 2000-2005 Cadillac DeVille, 2006-2011 Cadillac DTS, 2006-2014 Chevrolet Impala, and 2006-2007 Chevrolet Monte Carlo vehicles. In the affected vehicles, the weight on the key ring and road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.

The risk: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury. Additionally, a key knocked out of the run position will cause loss of engine power, power steering, and power braking, increasing the risk of a vehicle crash.

The fix: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 23, 2014. Owners may contact General Motors customer service at 1-800-521-7300 (Buick), 1-800-458-8006 (Cadillac), and 1-800-222-1020 (Chevrolet). GM's number for this recall is 14299.

Component: Powertrain / transmission (automatic transmission)

Impala model years: 2014 · about 355 vehicles in the whole campaign

The problem: General Motors LLC (GM) is recalling certain model year 2014 Buick Regal, LaCrosse, Verano, and Enclave, and Chevrolet Impala, Malibu, Cruze, and Traverse, and GMC Acadia vehicles equipped with automatic transmissions. In the affected vehicles, the transmission shift cable adjuster may disengage from the transmission shift lever. As such, these vehicles do not conform to Federal Motor Vehicle Safety Standard (FMVSS) number 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect." They also fail to conform to FMVSS number 114, "Theft Protection and Rollaway Prevention."

The risk: If a vehicle's shift cable disengages from the transmission shift lever, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the driver may be able to shift the lever to the "PARK" position, but the vehicle transmission may not be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.

The fix: General Motors will notify owners, and dealers will inspect and replace any affected transmission shift cable adjusters, free of charge. The recall began on April 10, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Buick owners at 1-800-521-7300, and GMC owners at 1-800-462-8782. General Motors' number associated with this recall is 14048.

Component: Exterior lighting (brake lights)

Impala model years: 2014 · about 10,210 vehicles in the whole campaign

The problem: General Motors LLC (GM) is recalling certain model year 2013 Cadillac ATS and model year 2013 Cadillac XTS; model year 2014 Chevrolet Impala; and 2013 Chevrolet Sonic vehicles. Originally, in May 2013, GM recalled 1,627 model year 2013 Cadillac ATS and model year 2013 Cadillac XTS; and model year 2014 Chevrolet Impala vehicles. In October 2013, GM informed the agency that it was adding model year 2013 Chevrolet Sonic vehicles to this campaign , representing an additional 8,050 units. The total number of vehicles being recalled is now 9,677. On the affected vehicles, the brake lamps may intermittently flash without the brakes being applied and the cruise control may disengage. Thus, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, reflective devices, and associated equipment."

The risk: If the brake lamps flash when the vehicle is not slowing, a following driver may not adjust vehicle speed when the vehicle is in fact braking, and the brake lamps are illuminating as intended, increasing the risk of a crash.

The fix: GM will notify owners, and dealers will reprogram the body control module. The recall began on June 13, 2013. Owner's may contact Chevrolet at 1-800-630-2438 or Cadillac at 1-866-982-2339. GM's recall number is 13158.

Component: Suspension (front, control arm, lower arm)

Impala model years: 2008–2012 · about 36,413 vehicles in the whole campaign

The problem: General Motors (GM) is recalling certain model year 2008-2012 Chevrolet Impala police vehicles because the front lower control arms may fracture. This safety recall does not include non-police Chevrolet Impala vehicles.

The risk: A broken control arm can result in the loss of control of the vehicle, increasing the risk of a crash.

The fix: GM will notify owners, and dealers will replace both front lower control arms, free of charge. The safety recall began on August 21, 2012. Owners may contact the Chevrolet owner center at 1-866-694-6546.

Component: Steering (hydraulic power assist, hose, piping)

Impala model years: 2012 · about 10,344 vehicles in the whole campaign

The problem: GM IS RECALLING CERTAIN MODEL YEAR 2012 CHEVROLET IMPALA VEHICLES MANUFACTURED FROM APRIL 19, 2011, THROUGH JULY 29, 2011. THE UPPER POWER STEERING HOSE MAY HAVE BEEN MISROUTED SO THAT IT CAN COME IN CLOSE PROXIMITY TO AND/OR CONTACT THE CATALYTIC CONVERTER. WITH THE ENGINE ON, HEAT FROM THE CATALYTIC CONVERTER MAY MELT THE POWER STEERING HOSE.

The risk: POWER STEERING FLUID COULD FLOW ONTO THE CATALYTIC CONVERTER, AND AN ENGINE COMPARTMENT FIRE COULD OCCUR.

The fix: GM DEALERS WILL INSPECT TO ENSURE THAT THE UPPER POWER STEERING HOSE IS ROUTED CORRECTLY AND MAKE THE NECESSARY REPAIRS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 5, 2011. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.

Component: Seat belts (front, anchorage)

Impala model years: 2009–2010 · about 303,100 vehicles in the whole campaign

The problem: GM IS RECALLING CERTAIN MODEL YEAR 2009-2010 CHEVROLET IMPALAS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." THE FRONT SAFETY BELT WEBBING MAY NOT HAVE BEEN PROPERLY SECURED TO THE LAP BELT ANCHOR PRETENSIONER MOUNTED TO THE SIDE OF THE SEAT NEAREST THE DOOR.

The risk: THE SAFETY BELT MAY NOT RESTRAIN THE OCCUPANT AS INTENDED DURING A CRASH, WHICH COULD RESULT IN INJURY TO THE OCCUPANT.

The fix: DEALERS WILL INSPECT BOTH FRONT SAFETY BELTS FOR PROPER INSTALLATION OF THE ANCHORS TO THE PRETENSIONERS AND, IF NECESSARY, REINSTALL THE ANCHORS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 5, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

Component: Engine & cooling

Impala model years: 2000–2003 · about 1,497,516 vehicles in the whole campaign

The problem: GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.

The risk: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.

The fix: DEALERS WILL REPLACE THE ENGINE’S FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINE’S PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.

Component: Steering

Impala model years: 2000–2007 · about 979 vehicles in the whole campaign

The problem: DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.

The risk: A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.

The fix: DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492 AND PRESS 5.

Component: Steering

Impala model years: 2000–2005 · about 3,855 vehicles in the whole campaign

The problem: DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.

The risk: IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.

The fix: DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.

Component: Air bags (frontal)

Impala model years: 2009 · about 79 vehicles in the whole campaign

The problem: GM IS RECALLING 79 MY 2009 CHEVROLET IMPALA VEHICLES. SOME OF THESE VEHICLES HAVE A PASSENGER-SIDE FRONT AIR BAG INFLATOR THAT COULD FRACTURE AT AN INFLATOR TUBE DURING A DEPLOYMENT.

The risk: DURING A PASSENGER-SIDE AIR BAG DEPLOYMENT, PIECES OF THE INFLATOR TUBE COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE PASSENGER.

The fix: DEALERS WILL INSTALL A NEW PASSENGER-SIDE FRONT AIR BAG. THE RECALL BEGAN ON OCTOBER 10, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .

Component: Fuel system

Impala model years: 2000–2005 · about 742 vehicles in the whole campaign

The problem: CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.

The risk: FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.

The fix: DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

Component: Fuel system

Impala model years: 2007 · about 1,602 vehicles in the whole campaign

The problem: ON CERTAIN VEHICLES, THE FUEL TANK IS MISSING THE ADHESIVE LAYER THAT BONDS THE BARRIER LAYER TO THE OUTER SHELL OF THE FUEL TANK.

The risk: WITH THIS CONDITION, FUEL AND/OR FUEL VAPORS COULD SEEP OUT BETWEEN THE LAYERS, INCREASING THE RISK OF A FIRE.

The fix: DEALERS WILL INSPECT THE SERIAL NUMBER ON THE FUEL TANK AND REPLACE THE FUEL TANK IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 13, 2006. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, OR PONTIAC AT 1-800-620-7668.

Component: Exterior lighting

Impala model years: 1995–1996 · about 61,944 vehicles in the whole campaign

The problem: CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

The risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

The fix: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

Component: Service brakes

Impala model years: 2004 · about 47,991 vehicles in the whole campaign

The problem: CERTAIN PASSENGER VEHICLES WERE PRODUCED WITH LOWER THAN SPECIFIED TORQUE ON BOTH FRONT BRAKE CALIPER TO STEERING KNUCKLE ATTACHMENT BOLTS. WITH IMPROPER TORQUE, THE CLAMP LOAD AT THE JOINT MAY NOT BE ADEQUATE TO PREVENT MOVEMENT BETWEEN THE CALIPER BRACKET AND KNUCKLE.

The risk: DEPENDING ON WHETHER ONE OR BOTH BOLTS BACKS OUT OR FRACTURES, THE RESULT CAN BE LOCKING OF THE AFFECTED WHEEL DURING BRAKING AND AN ABRUPT STEERING INPUT IN THE DIRECTION OF THE LOCKED WHEEL, REDUCED BRAKING AND NOISE FROM THE AFFECTED WHEEL, OR SEVERING OF A BRAKE HOSE, INCREASED BRAKE PEDAL TRAVEL, AND REDUCED STEERING CONTROL. REDUCED BRAKING OR STEERING CONTROL COULD CAUSE A CRASH.

The fix: DEALERS ARE TO TIGHTEN BOTH BOLTS TO THE SPECIFIED TORQUE. OWNER NOTIFICATION BEGAN ON JUNE 28, 2004. OWNERS SHOULD CONTACT CHEVROLET 1-800-630-2438 OR PONTIAC 1-800-620-7668.

Component: Fuel system

Impala model years: 2000 · about 910,873 vehicles in the whole campaign

The problem: ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 3800 V6 (L36) ENGINES AND CERTAIN DELPHI FUEL PRESSURE REGULATORS, THE REGULATORS HAVE A MUCH HIGHER THAN USUAL RATE OF FUEL LEAKS. A LEAK CAN ALLOW FUEL TO ENTER THE INTAKE MANIFOLD THROUGH A VACUUM LINE. IF THE ENGINE DOES NOT START WHEN CRANKED, THE FUEL FROM THE LEAKING REGULATOR AND A MISTIMED SPARK CAN CAUSE A BACKFIRE.

The risk: THE BACKFIRE CAN RUPTURE THE INTAKE MANIFOLD. THE RUPTURE OF THE INTAKE MANIFOLD CAN DISPLACE A FUEL LINE, PULLING AN INJECTOR OUT OF PLACE, AND CAUSING A FUEL LEAK AND POSSIBLE FIRE.

The fix: DEALERS WILL INSTALL NEW FUEL PRESSURE REGULATORS WITH IMPROVED DIAPHRAGMS. THE RECALL WILL BE CONDUCTED IN PHASED MAILINGS. PHASE 1 BEGAN ON JUNE 30, 2004, AND PHASE 2 BEGAN ON SEPTEMBER 30, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, OLDSMOBILE AT 1-800-630-6537, OR PONTIAC AT 1-800-620-7668.

Component: Air bags (frontal, driver side, inflator module)

Impala model years: 2003 · about 130 vehicles in the whole campaign

The problem: ON CERTAIN MINI VANS, PASSENGER AND SPORT UTILITY VEHICLES, SOME OF THESE VEHICLES HAVE A DRIVER'S SIDE AIR BAG THAT MAY NOT DEPLOY AS DESIGNED. IN ADDITION, THE AIR BAG INFLATOR COULD RUPTURE.

The risk: THIS COULD RESULT IN REDUCED CAPABILITY OF THE AIR BAG TO PROTECT THE DRIVER. ALSO IF THE AIR BAG INFLATOR RUPTURED, PIECES OF THE INFLATOR COULD STRIKE AND INJURE THE VEHICLE OCCUPANTS.

The fix: DEALERS WILL INSPECT, AND IF NECESSARY, INSTALL A NEW DRIVER'S AIR BAG. OWNER NOTIFICATION BEGAN ON MARCH 11, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR PONTIAC AT 1-800-762-2737.

Component: Air bags (frontal)

Impala model years: 2002–2003 · about 133,221 vehicles in the whole campaign

The problem: CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.

The risk: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.

The fix: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.

Component: Fuel system

Impala model years: 2000–2001 · about 126,745 vehicles in the whole campaign

The problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.4L ENGINE AND NON-ANTILOCK BRAKING SYSTEM (ABS). THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." A FUEL RETURN LINE CAN BECOME SEVERED IN A FRONTAL COLLISION, RESULTING IN FUEL SPILLAGE.

The risk: IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD OCCUR.

The fix: DEALERS WILL INSTALL A BRAKE MASTER CYLINDER BRACKET THAT WILL MAINTAIN POSITIONING OF THE FUEL LINE IN A FRONTAL CRASH. OWNER NOTIFICATION BEGAN JUNE 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.

Component: Air bags (side/window)

Impala model years: 2000–2001 · about 12 vehicles in the whole campaign

The problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE DRIVER SIDE IMPACT AIR BAG INFLATOR SEPARATES FROM THE AIR BAG MODULE DURING DEPLOYMENT.

The risk: IF THE INFLATOR SEPARATES, THE AIR BAG WILL NOT DEPLOY PROPERLY DURING A CRASH AND OCCUPANT PROTECTION WOULD BE REDUCED. IF IS ALSO POSSIBLE THAT A SEPARATED INFLATOR COULD BE PROPELLED DOWNWARD AND COULD RESULT IN INJURY TO A REAR SEAT PASSENGER WHOSE FOOT IS POSITIONED APPROXIMATELY UNDER THE INFLATOR MODULE.

The fix: DEALERS WILL REPLACE THE SIDE IMPACT AIR BAG MODULE.

Component: Air bags

Impala model years: 2001 · about 580 vehicles in the whole campaign

The problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE AIR BAG SENSING AND DIAGNOSTIC MODULES (SDM) COULD EXPERIENCE A MEMORY ERROR RESULTING IN THE AIR BAGS NOT DEPLOYING IN A CRASH SITUATION.

The risk: IN A CRASH, A FRONT SEAT OCCUPANT MAY RECEIVE MORE SERIOUS INJURIES.

The fix: DEALERS WILL REPLACE THE SENSING AND DIAGNOSTIC MODULE.

Component: Seat belts

Impala model years: 2000–2001 · about 156,305 vehicles in the whole campaign

The problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."

The risk: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.

The fix: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.