Dodge Avenger Recalls: Every NHTSA Recall by Model Year

Component: Seats (front assembly, head restraint)

Avenger model years: 2012–2013 · about 363,930 vehicles in the whole campaign

The problem: Chrysler (FCA US LLC) is recalling certain 2012 Jeep Liberty and 2012-2013 Chrysler 200 and Dodge Avenger vehicles. A component within the occupant restraint controller (ORC) may fail and prevent the active headrests from deploying in the event of a rear-end crash.

The risk: If the active headrests do not deploy in certain rear-end crashes, the front seat occupants have an increased risk of injury.

The fix: Chrysler will notify owners, and dealers will replace the ORC as necessary, free of charge. The recall began on December 4, 2017. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is T56.

Component: Air bags

Avenger model years: 2010–2014 · about 1,435,625 vehicles in the whole campaign

The problem: Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.

The risk: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.

The fix: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.

Component: Engine

Avenger model years: 2013 · about 521 vehicles in the whole campaign

The problem: Chrysler Group LLC (Chrysler) is recalling certain model year 2013 Dodge Avenger and Chrysler 200, and model year 2014 Jeep Compass and Patriot vehicles equipped with 2.4L engines. Due to abrasive debris in the balance shaft bearings, these engines may have a loss of engine oil pressure, possibly resulting in an engine stall or engine failure.

The risk: If the engine stalls while driving it may increase the risk of a crash.

The fix: Chrysler will notify owners, and dealers will replace the engine balance shaft module, free of charge. The recall began on December 24, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N52.

Component: Air bags

Avenger model years: 2011–2013 · about 442,320 vehicles in the whole campaign

The problem: Chrysler is recalling certain model year 2011-2013 Sebring and 200 vehicles manufactured June 28, 2011, through December 13, 2012; model year 2011-2013 Dodge Avenger vehicles manufactured June 25, 2011, through January 14, 2013; model year 2011-2012 Dodge Nitro vehicles manufactured June 17, 2011, through December 15, 2011; and model year 2011-2012 Jeep Liberty vehicles manufactured June 17, 2011, through August 15, 2012. Electrical over-stress of a resistor in the occupant restraint control module may lead to the non-deployment of the active head restraints during a rear impact collision.

The risk: In the event of a crash necessitating the deployment of the active head restraints , their non-deployment could increase the risk of injury.

The fix: Chrysler will notify owners, and dealers will flash the Totally Integrated Power Module (TIPM) or replace the occupant restraint control module, as needed, free of charge. The recall began on November 19, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N38.

Component: Fuel system

Avenger model years: 2013 · about 1,785 vehicles in the whole campaign

The problem: Chrysler is recalling certain model year 2013 Chrysler 200 and Dodge Avenger vehicles manufactured from October 30, 2012, through November 2, 2012. These vehicles may have a gas tank that has a broken control valve in the fuel tank assembly.

The risk: A broken control valve in the fuel tank assembly may lead to an engine stall or fuel leakage. An engine stall while driving may contribute to a vehicle crash. Fuel leakage, in the presence of an ignition source, may result in a fire.

The fix: Chrysler will notify owners, and dealers will inspect the fuel tank assembly and replace any affected control valves, free of charge. The recall began on April 4, 2013. Owners may contact Chrysler at 1-800-247-9753.

Component: Steering (column)

Avenger model years: 2011 · about 11,096 vehicles in the whole campaign

The problem: CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011DODGE JOURNEY, JEEP WRANGLER, CHRYSLER 200, CHRYSLER 200 CONVERTIBLE, DODGE AVENGER, DODGE NITRO, JEEP LIBERTY, DODGE CALIBER, JEEP COMPASS, JEEP PATRIOT, DODGE GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY VEHICLES. SOME OF THESE VEHICLES MAY HAVE BEEN BUILT WITH A MISSING OR INCORRECTLY INSTALLED STEERING COLUMN PIVOT RIVET.

The risk: A MISSING OR INCORRECTLY INSTALLED RIVET COULD COMPROMISE THE ABILITY OF THE STEERING COLUMN TO SUPPORT THE OCCUPANT LOADS IN THE EVENT OF A FRONTAL CRASH, DECREASING THE EFFECTIVENESS OF THE FRONTAL IMPACT SAFETY SYSTEM. AS A RESULT, THE CONDITION MAY INCREASE THE POTENTIAL FOR INJURY IN A FRONTAL CRASH.

The fix: DEALERS WILL INSPECT FOR RIVET PRESENCE AND ALIGNMENT AND REPAIR THE STEERING COLUMN PIVOT AS REQUIRED, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 4, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Component: Steering (electric power assist system)

Avenger model years: 2010 · about 23,237 vehicles in the whole campaign

The problem: CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2010 CHRYSLER SEBRING, 300, CHARGER (LX) AND DODGE CHALLENGER (LC), AVENGER (JS), AND JOURNEY (JC), AS WELL AS MODEL YEAR 2011 DODGE RAM LIGHT DUTY PICKUP (DS) VEHICLES. SOME OF THESE VEHICLES MAY EXPERIENCE A SEPARATION AT THE CRIMPED END OF THE POWER STEERING PRESSURE HOSE ASSEMBLY.

The risk: LEAKED POWER STEERING FLUID ONTO HOT ENGINE COMPONENTS COULD CAUSE A FIRE.

The fix: DEALERS WILL INSPECT AND REPLACE AS NECESSARY THE POWER STEERING PRESSURE HOSES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 20, 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Component: Service brakes

Avenger model years: 2010 · about 20,045 vehicles in the whole campaign

The problem: CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2010 CHRYSLER SEBRING; DODGE AVENGER AND NITRO; JEEP LIBERTY, COMMANDER AND GRAND CHEROKEE; AND MODEL YEAR 2009-2010 DODGE RAM TRUCK. THESE VEHICLES MAY HAVE BEEN BUILT WITH AN IMPROPERLY FORMED OR MISSING BRAKE BOOSTER INPUT ROD RETAINING CLIP.

The risk: THIS COULD RESULT IN BRAKE FAILURE WITHOUT WARNING WHICH COULD CAUSE A CRASH.

The fix: CHRYSLER WILL REPLACE THE BRAKE BOOSTER INPUT ROD RETAINING CLIP FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING FEBRUARY 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Component: Exterior lighting (headlights)

Avenger model years: 1997–2000 · about 42,540 vehicles in the whole campaign

The problem: DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

The risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

The fix: DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

Component: Exterior lighting

Avenger model years: 1997–2000 · about 16,270 vehicles in the whole campaign

The problem: SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

The risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

The fix: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Component: Fuel system

Avenger model years: 2009 · about 91 vehicles in the whole campaign

The problem: CHRYSLER IS RECALLING 91 MY 2009 SEBRING AND DODGE AVENGER EQUIPPED WITH 2.4L ENGINE PASSENGER VEHICLES. A COMPATIBILITY ISSUE BETWEEN THE INSTRUMENT CLUSTER SOFTWARE AND FUEL PUMP MODULE CAN RESULT IN THE FUEL GAUGE OVERSTATING THE ACTUAL FUEL TANK LEVEL. AS A RESULT, THE VEHICLE MAY RUN OUT OF FUEL WHEN THE GAUGE INDICATES THAT THERE IS STILL FUEL REMAINING IN THE TANK.

The risk: THIS COULD CAUSE A CRASH WITHOUT WARNING.

The fix: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MARCH 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Component: Powertrain / transmission (automatic transmission, control module (tcm/pcm/tecm))

Avenger model years: 2009 · about 712 vehicles in the whole campaign

The problem: CHRYSLER IS RECALLING 712 MY 2009 SEBRING, DODGE CALIBER, AVENGER, JOURNEY, JEEP PATRIOT, AND COMPASS VEHICLES. A NEW ADHESIVE USED IN THE POWER TRAIN CONTROL MODULE (PCM) MANUFACTURING PROCESS CAN CAUSE THE PRINTED CIRCUIT BOARD TO BREAK.

The risk: THIS CAN CAUSE THE ENGINE TO STALL AND CAUSE A CRASH WITHOUT WARNING.

The fix: DEALERS WILL REPLACE THE PCM FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 10, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Component: Electrical system (wiring)

Avenger model years: 2007–2008 · about 180,963 vehicles in the whole campaign

The problem: CHRYSLER IS RECALLING 180,963 MY 2007-2008 SEBRING AND DODGE AVENGER VEHICLES EQUIPPED WITH A STANDARD TIRE PRESSURE MONITORING SYSTEM (TPMS). UNUSED ELECTRICAL CONNECTORS FOR THE TPMS MAY BECOME CORRODED AND COULD SHORT CIRCUIT, WHICH CAN CAUSE A VARIETY OF CONDITIONS INCLUDING ENGINE NO-START, DEAD BATTERY, AN INOPERATIVE CRUISE CONTROL OR REMOTE START SYSTEM, AND/OR ENGINE STALLING.

The risk: ENGINE STALLING COULD CAUSE A CRASH WITHOUT WARNING.

The fix: DEALERS WILL SEAL THE WIRES FOR THE TPMS FREE OF CHARGE. THE RECALL BEGAN ON APRIL 15, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Component: Engine & cooling (cooling system, radiator assembly)

Avenger model years: 2007–2008 · about 102,042 vehicles in the whole campaign

The problem: ON CERTAIN VEHICLES EQUIPPED WITH 2.4 LITER ENGINES, THE ENGINE COOLANT MAY BE DRAWN INTO THE LEFT RADIATOR COOLING FAN MOTOR CONNECTOR.

The risk: THIS CAN CAUSE AN ELECTRICAL SHORT CIRCUIT AND RESULT IN AN ENGINE COMPARTMENT FIRE.

The fix: DEALERS WILL INSPECT THE CONNECTOR FOR CONTAMINATION OR DAMAGE, INSTALL A WIRING HARNESS OVERLAY, AND REPLACE THE FAN MOTOR FREE OR CHARGE. THE RECALL BEGAN ON NOVEMBER 19, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Component: Fuel system

Avenger model years: 2008 · about 1,158 vehicles in the whole campaign

The problem: ON CERTAIN VEHICLES WITH ALL WHEEL DRIVE, THE FUEL TANK STRAPS WERE IMPROPERLY MANUFACTURED AND COULD SEPARATE. THIS CAN CAUSE THE FUEL TANK TO LOOSEN AND LEAK FUEL.

The risk: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERBODY FIRE.

The fix: DEALERS WILL REPLACE THE FUEL TANK RETENTION STRAPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING OCTOBER 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Component: Latches, locks & linkages (doors, latch)

Avenger model years: 2007–2008 · about 72,333 vehicles in the whole campaign

The problem: ON CERTAIN VEHICLES, THE FRONT DOOR LATCH CABLE MAY BECOME PARTIALLY UNSEATED FROM THE INTERIOR RELEASE HANDLE HOUSING POSSIBLY CAUSING THE LATCH TO STICK IN THE UNLATCHED POSITION OR THE LOCK FUNCTION TO BECOME INOPERATIVE.

The risk: DRIVING A VEHICLE WITH AN UNLATCHED DOOR CAN RESULT IN AN UNBELTED FRONT SEAT OCCUPANT FALLING OUT OF THE VEHICLE OR BEING EJECTED IN A CRASH, CAUSING INCREASED RISK OF INJURY.

The fix: DEALERS WILL ADD A SECONDARY RETENTION FEATURE TO BOTH FRONT DOORS. THIS ACTION WILL SUPERSEDE AND EXPAND A PREVIOUS SAFETY RECALL (PLEASE SEE 07V-104). THE RECALL BEGAN ON OCTOBER 29, 2007. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Component: Fuel system

Avenger model years: 1995–2000 · about 222 vehicles in the whole campaign

The problem: CERTAIN AIRTEX FUEL PUMP MODULE ASSEMBLIES, P/N E7081H, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE WALL OF THE FLARED FITTING OF THE FUEL PUMP IS NOT THICK ENOUGH TO PREVENT THE MATING THREADED FITTINGS FROM BOTTOMING OUT BEFORE AN ADEQUATE SEAL IS ACHIEVED. THIS CONDITION MAY RESULT IN LEAKAGE OF FUEL AT THE CONNECTION OF THE VEHICLE FUEL LINE AND THE FUEL PUMP MODULE ASSEMBLY.

The risk: IN THE PRESENCE OF AN IGNITION SOURCE, A FUEL LEAK COULD RESULT IN A FIRE.

The fix: AIRTEX WILL NOTIFY OWNERS AND REPLACE THE FUEL PUMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2007. OWNERS CAN CONTACT AIRTEX AUTOMOTIVE AT 800-880-3056.

Component: Air bags (frontal)

Avenger model years: 2008 · about 798 vehicles in the whole campaign

The problem: ON CERTAIN PASSENGER VEHICLES, THE FRONT SEAT TRACK POSITION SENSORS UTILIZED FOR THE AIR BAG SYSTEM MAY NOT FUNCTION PROPERLY.

The risk: THIS COULD INCREASE THE RISK OF INJURY TO FRONT SEAT OCCUPANTS DURING CERTAIN CRASH CONDITIONS.

The fix: DEALERS WILL INSPECT THE FRONT SEAT TRACK POSITION SENSORS AND REPLACE THEM FREE OF CHARGE. THE RECALLBEGAN ON JUNE 18, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Component: Latches, locks & linkages (doors, latch)

Avenger model years: 2007–2008 · about 11,191 vehicles in the whole campaign

The problem: ON CERTAIN PASSENGER VEHICLES, THE FRONT DOOR LATCH CABLE MAY BECOME PARTIALLY UNSEATED FROM THE INTERIOR RELEASE HANDLE HOUSING CAUSING THE DOOR LATCH TO STICK IN THE OPEN POSITION AND NOT BE SECURED TO THE STRIKER.

The risk: DURING CERTAIN CRASH CONDITIONS, THE POSSIBILITY OF A DOOR OPENING COULD CAUSE AN UNBELTED PASSENGER TO BE EJECTED, INCREASING THE RISK OF INJURIES.

The fix: THIS ACTION IS SUPERSEDED (PLEASE SEE 07-V414.) DEALERS WILL ADD FREE OF CHARGE A SECONDARY FEATURE TO BOTH FRONT DOORS TO PREVENT THE DOOR LATCH CABLE FERRULE FROM BECOMING UNSEATED AT THE INTERIOR FRONT DOOR RELEASE HANDLE HOUSING. THE RECALL BEGAN ON APRIL 30, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Component: Exterior lighting

Avenger model years: 1997–2000 · about 4,029 vehicles in the whole campaign

The problem: CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

The risk: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.

The fix: TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.

Component: Suspension (front, control arm, lower ball joint)

Avenger model years: 1995–2000 · about 393,796 vehicles in the whole campaign

The problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE.

The risk: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH. THIS CAMPAIGN SUPERCEDES MMC'S PREVIOUS SAFETY RECALL CAMPAIGN, SEE 99V-066.

The fix: DEALERS WILL INSPECT THE LOWER LATERAL ARM BALL JOINT FOR WEAR. BALL JOINTS THAT EXHIBIT WEAR BEYOND THE ESTABLISHED TOLERANCE WILL BE REPLACED WITH NEWLY DESIGNED LATERAL ARM BALL JOINTS. BALL JOINTS THAT ARE WITHIN THE ESTABLISHED TOLERANCE WILL BE CLEANED AND A SPECIAL SEALANT WILL BE APPLIED TO PREVENT INTRUSION OF MOISTURE.

Component: Suspension (front, control arm, lower ball joint)

Avenger model years: 1995–1996 · about 165,857 vehicles in the whole campaign

The problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE.

The risk: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH.

The fix: DEALERS WILL INSPECT THE RUBBER BOOTS, AND IF THE BOOT IS DAMAGED, THEY WILL REPLACE THE LOWER LATERAL ARM AND BALL JOINT ON THE AFFECTED VEHICLES.

Component: Speed control / throttle

Avenger model years: 1998 · about 27,527 vehicles in the whole campaign

The problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE DASH PANEL PAD CAN SHIFT INTERFERRING WITH THE THROTTLE CABLE CONTROL.

The risk: THE THROTTLE CABLE CONTROL WOULD NOT RETURN TO IDLE INCREASING THE RISK OF A VEHICLE CRASH.

The fix: DEALERS WILL REMOVE A PORTION OF THE DASH PANEL PAD SO IT CANNOT INTERFERE WITH THE THROTTLE CABLE CONTROL.

Component: Seats (front assembly, head restraint)

Avenger model years: 1997 · about 1,083 vehicles in the whole campaign

The problem: THE HEADREST GUIDE BRACKET WAS IMPROPERLY WELDED TO THE SEAT BACK FRAME ON THE PASSENGER SIDE SEAT BACK ASSEMBLIES ONLY.

The risk: THE HEADREST SUPPORT BRACKET CAN BREAK, INCREASING THE RISK OF PERSONAL INJURY.

The fix: DEALERS WILL REPLACE THE PASSENGER SEAT BACK ASSEMBLY WITH A NEW ASSEMBLY.