Ford Taurus Recalls: Every NHTSA Recall by Model Year

Component: Backup camera / back-over prevention (sensing system, camera)

Taurus model years: 2015–2016, 2018–2019 · about 1,448,655 vehicles in the whole campaign

The problem: Ford Motor Company (Ford) is recalling certain 2015-2019 Flex, 2015 Explorer, Lincoln MKT, Lincoln MKZ, 2015-2016 C-Max, Escape, Taurus, 2016 Fusion, 2018-2019 Taurus, 2019 Lincoln MKT, Fiesta, and 2020 Mustang vehicles. The rearview camera may display a distorted, intermittent, or blank image when the vehicle is in reverse.

The risk: A rearview camera that fails to properly display an image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.

The fix: Dealers will inspect and replace the rearview camera as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters notifying owners of the safety risk were mailed on October 25, 2025. Additional letters will be mailed once the final remedy is available on each phase. Mustang owner notification letters were mailed January 2, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA9. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 14, 2025.

Component: Structure (exterior trim)

Taurus model years: 2016–2019 · about 101,944 vehicles in the whole campaign

The problem: Ford Motor Company (Ford) is recalling certain 2016-2019 Taurus vehicles. The driver and front passenger B-Pillar door trim may detach while driving.

The risk: Door trim that detaches while driving can create a road hazard, increasing the risk of a crash.

The fix: Dealers will repair or replace the B-pillar trim as necessary, free of charge. Owner notification letters were mailed February 20, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S91.

Component: Powertrain / transmission (axle assembly, axle shaft)

Taurus model years: 2014–2015 · about 15,587 vehicles in the whole campaign

The problem: Ford Motor Company (Ford) is recalling certain 2014-2016 Explorer, 2014-2015 Taurus and 2014 Edge vehicles equipped with 2.0L or 2.3L engines and front wheel drive. The support bracket for the front drive axle halfshaft may fail.

The risk: The failed bracket could result in a loss of park function which can cause unintended vehicle movement, and loss of motive power while driving which increases the risk of a crash.

The fix: Ford will notify owners, and dealers will replace the link shaft bracket, free of charge. Parts are not currently available. Owners received an interim notification detailing safety risk December 8, 2020. A second letter will be mailed when parts become available in January 2021. The recall began February 2, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S63.

Component: Suspension (rear)

Taurus model years: 2013–2018 · about 211,207 vehicles in the whole campaign

The problem: Ford Motor Company (Ford) is recalling certain 2013-2018 Lincoln MKT and Ford Flex and Taurus vehicles with the Police Interceptor or SHO Performance Pack. The rear suspension toe links may fracture due to stress on the rear suspension.

The risk: A fractured rear toe link will cause a sudden change in vehicle handling and increase the risk of a crash.

The fix: Ford will notify owners, and dealers will replace the rear suspension toe links, free of charge. Remedy parts are not currently available. Owners were notified about the recall on March 3, 2020. A second notice will be mailed when remedy parts become available, which is currently expected to be the end of September 2020. The recall began October 28, 2020. Owners may contact Ford customer service at 1-866-436-7332 or Lincoln customer service at 1-800-521-4140. Ford's number for this recall is 20S04.

Component: Electrical system (ignition)

Taurus model years: 2017–2018 · about 2,100 vehicles in the whole campaign

The problem: Ford Motor Company (Ford) is recalling certain 2017-2018 Ford Taurus vehicles equipped with mechanical key ignition systems. The keys for these vehicles may be able to be removed from the ignition when transmission is not in the PARK position. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection."

The risk: If the key is removed from the ignition while the vehicle is not in the PARK position and the parking brake is not applied, the vehicle may roll away, increasing the risk of a crash.

The fix: Ford will notify owners, and dealers will replace the shifter assembly, free of charge. The recall began May 11, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18C02.

Component: Steering

Taurus model years: 2017 · about 253 vehicles in the whole campaign

The problem: Ford Motor Company (Ford) is recalling certain 2017 Explorer, Taurus and Police Interceptor Utility and Sedan vehicles. The steering gear heat shield fasteners may corrode, allowing the heat shield to detach.

The risk: If the heat shield detaches, the steering gear may overheat, increasing the steering effort required by the driver, especially at lower speeds, and increasing the risk of a crash.

The fix: Ford will notify owners, and dealers to inspect and replace the heat shield fasteners as needed, free of charge. The recall began on September 13, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S23.

Component: Engine & cooling (engine, gasoline, turbo/supercharger)

Taurus model years: 2016 · about 1,163 vehicles in the whole campaign

The problem: Ford Motor Company (Ford) is recalling certain model year 2016 Ford Taurus, 2016-2017 Ford Flex, Lincoln MKT, 2017 Ford Explorer and Ford Explorer Police Interceptor Utility vehicles equipped with 3.5L GTDI engines. Improperly brazed turbocharger oil supply tubes may leak oil on engine components.

The risk: An oil leak, in the presence of an ignition source, increases the risk of a fire.

The fix: Ford will notify owners, and dealers will inspect, and if necessary, replace the turbocharger oil supply tubes, free of charge. The recall began on January 31, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S46.

Component: Fuel system

Taurus model years: 2013–2015 · about 77,502 vehicles in the whole campaign

The problem: Ford Motor Company (Ford) is recalling certain model year 2013-2015 Ford Taurus, Ford Flex, Lincoln MKS and Lincoln MKT vehicles equipped with 3.5L GTDI Ecoboost engines and 2013-2015 Ford Taurus Police Interceptor vehicles. A component within the fuel pump electric module (PEM) may overheat causing a loss of electrical power to the fuel pump.

The risk: A loss of power to the fuel pump will cause the engine to stall or prevent the vehicle from starting, increasing the risk of a crash.

The fix: Ford will notify owners, and dealers will inspect the fuel PEM part number and replace the fuel PEM, as necessary, free of charge. The recall began on December 1, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S31.

Component: Air bags (frontal)

Taurus model years: 2008, 2010–2012 · about 695 vehicles in the whole campaign

The problem: Ford Motor Company (Ford) is recalling certain model year 2009-2012 Ford Flex, 2008 and 2010-2012 Ford Taurus, 2008-2009 Ford Taurus X, 2008 Mercury Sable, 2009 and 2011 Lincoln MKS vehicles. The driver frontal air bag may improperly inflate during second-stage deployment in the event of a high speed crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."

The risk: An improperly inflated air bag increases the risk of injury in the event of a crash.

The fix: Ford will notify owners, and dealers will inspect and replace the driver's frontal air bag module, as necessary, free of charge. The recall is expected to begin on June 13, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16C06.

Component: Service brakes

Taurus model years: 2001–2007 · about 49,635 vehicles in the whole campaign

The problem: Bosch Brake Components LLC (Bosch) is recalling certain aftermarket replacement front brake pads, models Bosch QuietCast BC598 and BP765, Bosch Blue BE598 and BE598H, Prostop PD598 and PD765M, Duralast Gold DG598, Duralast MKD598, Stop Master ST598, UltraStop ULT598, UltraLife MX598 and MX765, BrakeBest MKD765, and Prostop Platinum PGD598. These brake pads, manufactured October 1, 2014, to October 31, 2015 are intended for use on 2001-2007 Ford Taurus, 2001-2005 Mercury Sable, 1995-1999 Ford Taurus SHO, 1995-2002 Lincoln Continental, and 1993-1998 Lincoln Mark VIII vehicles. The brake pad shim may shift out of position causing the shim to contact the brake disc resulting in damage to the disc.

The risk: A damaged or broken brake disc may reduce a vehicle's braking power, increasing the risk of a crash.

The fix: Bosch will instruct the owners how to have the affected brake pads replaced, free of charge. The recall began on May 26, 2016. Owners may contact Bosch customer service at 1-888-715-3616.

Component: Fuel system

Taurus model years: 2013 · about 868 vehicles in the whole campaign

The problem: Ford Motor Company (Ford) is recalling certain model year 2013 Explorer, Explorer Police Utility, Taurus, Taurus Police Interceptor, Flex, Lincoln MKS, and Lincoln MKT vehicles. In the affected vehicles, the fuel delivery module may crack, allowing fuel to leak.

The risk: A fuel leak in the presence of an ignition source may result in a fire.

The fix: Ford will notify owners, and dealers will replace the fuel delivery module, free of charge. The recall began on December 21, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 13S04-S1.

Component: Fuel system

Taurus model years: 2015 · about 203 vehicles in the whole campaign

The problem: Ford Motor Company (Ford) is recalling certain model year 2015 Ford Taurus, Lincoln MKS, and 2016 Ford Explorer vehicles manufactured on July 24, 2015. During vehicle production, the fuel tank attachment bolts may not have been properly tightened. As a result, the fuel tank straps may fracture and the fuel tank could separate from the vehicle.

The risk: If the fuel tank separates from the vehicle, a fuel leak may occur, increasing the risk of a fire.

The fix: Ford will notify owners, and dealers will tighten the fuel tank attachment bolts, as necessary, free of charge. The recall began on October 19, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S26.

Component: Parking brake

Taurus model years: 2015 · about 7,165 vehicles in the whole campaign

The problem: Ford Motor Company (Ford) is recalling certain model year 2015 Ford Taurus, Ford Flex, and Lincoln MKS vehicles manufactured May 4, 2015, to May 23, 2015, Lincoln MKT vehicles manufactured May 4, 2015, to May 21, 2015, and 2015-2016 Ford Explorer vehicles manufactured May 4, 2015, to May 23, 2015. The affected vehicles have a parking brake that may not fully engage when applied. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 135, "Light Vehicle Brake Systems."

The risk: If the parking brake does not fully engage and the transmission is left in a gear other than 'Park' while on a slope, the vehicle may roll away, increasing the risk of a crash.

The fix: Ford will notify owners, and dealers will test the operation of the parking brake system, and if necessary, replace the parking brake control assembly, free of charge. The recall began on September 4, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15C07.

Component: Steering (electric power assist system)

Taurus model years: 2011–2013 · about 393,623 vehicles in the whole campaign

The problem: Ford Motor Company (Ford) is recalling certain model year 2011-2012 Ford Fusion vehicles without a 3.5L engine and Lincoln MKZ hybrid electric vehicles, 2011 Mercury Milan vehicles, 2011-2012 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with a 3.5L GTDI engine and 2013 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with any available engine. The affected vehicles have electric power steering assist systems that may shut down as a result of a steering motor sensor fault.

The risk: If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, increasing the risk of a vehicle crash.

The fix: Ford will notify owners, and dealers will check the Power Steering Control Module (PSCM) for Diagnostic Trouble Codes (DTC). If dealers find any loss of steering assist DTCs, the steering gear will be replaced, free of charge. If, no codes are found during the PSCM inspection, the PSCM software will be updated, free of charge. The recall began on July 21, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S18.

Component: Structure (body, door)

Taurus model years: 2010–2013 · about 194,889 vehicles in the whole campaign

The problem: Ford Motor Company (Ford) is recalling certain model year 2010-2013 Ford Taurus vehicles manufactured December 1, 2009, to July 31, 2010, and 2011-2013 Lincoln MKS vehicles manufactured June 1, 2011, to October 31, 2011. In the affected vehicles, the interior door handle return spring may unseat, resulting in interior door handle that does not return to the fully stowed position after actuation.

The risk: If the interior door handle return spring is unseated, the door may unlatch in the event of a side impact crash, increasing the risk of personal injury.

The fix: Ford will notify owners, and dealers will inspect all four of the interior door handles and either repair or replace them, free of charge. The recall began March 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S02.

Component: Powertrain / transmission (axle assembly, axle shaft)

Taurus model years: 2013–2014 · about 83,250 vehicles in the whole campaign

The problem: Ford Motor Company (Ford) is recalling certain model year 2012-2014 Ford Edge and Lincoln MKX vehicles manufactured September 2, 2010, to November 30, 2013; 2013-2014 Ford Taurus and Lincoln MKS vehicles manufactured August 25, 2011, to November 30, 2013; and 2013-2014 Ford Flex and Lincoln MKT vehicles manufactured September 12, 2011, to November 30, 2013. In the affected vehicles, the halfshaft retention circlip may not have been properly installed, and as a result, the halfshaft may move outward and disengage from the linkshaft while driving and without prior warning.

The risk: If the halfshaft and linkshaft become disengaged while driving, power will no longer be transmitted to the wheels, increasing the risk of a vehicle crash. Additionally, if the parking brake is not applied before exiting the vehicle, the vehicle may roll away despite the transmission being placed in 'Park', increasing the risk of injury to exiting occupants and bystanders.

The fix: Ford will notify owners, and dealers will inspect the vehicles to make sure that the halfshaft is properly retained. If it is not, dealers will replace the linkshaft and also replace the halfshaft if it shows evidence of spline damage, free of charge. The recall began on August 4, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S10.

Component: Exterior lighting

Taurus model years: 2010–2014 · about 183,425 vehicles in the whole campaign

The problem: Ford Motor Company (Ford) is recalling certain model year 2010-2014 Taurus vehicles manufactured November 24, 2008, through February 28, 2014, originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. When used in areas that use road salt, the license plate lamp assembly may experience an electro-chemical reaction and corrosion as a result of water intrusion.

The risk: This corrosion may result in a short circuit, increasing the risk of a fire.

The fix: Ford will notify owners, and dealers will replace the license plate lamp assemblies, free of charge. The recall began on July 26, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S08. Note: Under program 14R01, Ford will notify owners in non-corrosion states, and, at the customer's request, dealers will replace the license plate lamp assembly.

Component: Latches, locks & linkages

Taurus model years: 2013 · about 12,569 vehicles in the whole campaign

The problem: Ford Motor Company (Ford) is recalling certain model year 2013 Ford Explorer, Taurus, and Lincoln MKS vehicles manufactured November 29, 2012, through December 12, 2012. In the affected vehicles, with sufficient door openings and closings, the child safety locks may change from an activated position to a deactivated position without notice.

The risk: If the child lock is deactivated, the door could be unlocked and opened from the inside which could lead to personal injury to an unrestrained child.

The fix: Ford will notify owners, and dealers will test the safety locks. If necessary, the locks will be replaced free of charge. The recall began on August 2, 2013. Ford's recall number is 13S07. Owners may contact the Ford customer relationship center at 1-866-436-7332.

Component: Fuel system

Taurus model years: 2013 · about 390,783 vehicles in the whole campaign

The problem: Ford is recalling certain model year 2013 Explorer, Taurus, Flex, Fusion, Police Interceptor Sedan and Police Interceptor Utility vehicles; and certain model year 2013 Lincoln MKS, MKT, and MKZ vehicles. In the affected vehicles, the fuel delivery module may develop a crack, allowing fuel to leak.

The risk: A fuel leak in the presence of an ignition source may result in a fire.

The fix: Ford will notify owners, and dealers will replace the fuel delivery module, free of charge. The recall began on July 20, 2013. Owners may contact Ford Motor Company Customer Relationship Center at 1-866-436-7332. Ford's recall campaign number is 13S04.

Component: Fuel system

Taurus model years: 2012 · about 3,037 vehicles in the whole campaign

The problem: Ford is recalling certain model year 2012 Taurus, Lincoln MKS, and model year 2013 Explorer vehicles manufactured July 19, 2011, through March 15, 2012. In the affected vehicles, the fuel tanks may have a marginally sealed seam in the side of the tank. As a result, the fuel tanks may not provide the expected strength in the event of an impact. The tanks may also leak.

The risk: A fuel leak in the presence of an ignition source may result in a fire.

The fix: Ford will notify owners, and dealers will inspect the fuel tanks and replace them as necessary, free of charge. The recall began on May 9, 2013. Ford's recall campaign number is 13S03. Owners may contact Ford Motor Company Customer Relationship Center at 1-866-436-7332.

Component: Exterior lighting

Taurus model years: 1996–1999 · about 16,270 vehicles in the whole campaign

The problem: SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

The risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

The fix: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Component: Electrical system (instrument cluster/panel)

Taurus model years: 2006 · about 19 vehicles in the whole campaign

The problem: CERTAIN PASSENGER VEHICLES BUILT FOR ONE SPECIFIC FLEET CUSTOMER WERE MODIFIED FOR OPTIONAL HANDS-FREE CELLULAR PHONE OPERATING CAPABILITY. TO PROVIDE THIS FUNCTIONALITY, A SPECIAL OVERLAY WIRE HARNESS WAS INSTALLED THAT INADVERTENTLY DID NOT INCLUDE THE CIRCUITS FOR PASSENGER AIR BAG DEACTIVATION INDICATOR (PADI) LAMP FUNCTION. AS A RESULT, THESE VEHICLES DO NOT COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.'

The risk: THE PADI LAMP WILL FAIL TO ILLUMINATE AND THE AIR BAG WARNING LAMP IN THE CLUSTER WILL STAY ILLUMINATED.

The fix: THE FLEET CUSTOMER WAS NOTIFIED AND ALL VEHICLES HAVE BEEN REPAIRED. THE RECALL BEGAN ON APRIL 28, 2006.

Component: Exterior lighting

Taurus model years: 1996–1999 · about 61,944 vehicles in the whole campaign

The problem: CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

The risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

The fix: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

Component: Visibility (windshield wiper/washer, motor)

Taurus model years: 2006 · about 199,942 vehicles in the whole campaign

The problem: ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.

The risk: AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.

The fix: DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR LINCOLN/MERCURY AT 1-800-521-4140.

Component: Suspension (front, springs, coil springs)

Taurus model years: 1999–2001 · about 899,060 vehicles in the whole campaign

The problem: ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, THE FRONT COIL SPRINGS COULD FRACTURE DUE TO CORROSION ASSOCIATED WITH SALT USED ON THE ROADWAYS DURING THE WINTER. A FRACTURED SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE.

The risk: IF THIS OCCURS, THE TIRE MAY RUPTURE RESULTING IN A RAPID AIR LOSS, WHICH COULD RESULT IN A CRASH.

The fix: DEALERS WILL INSTALL PROTECTIVE SPRING SHIELDS. IN ADDITION, FORD IS EXTENDING THE WARRANTY COVERAGE OF THE FRONT COIL SPRINGS IN ALL OTHER STATES, FOR FRACTURE ONLY, UP TO 10 YEARS OF SERVICE OR 150,000 MILES, WHICHEVER OCCURS FIRST. IF THE VEHICLE HAS ALREADY ACCUMULATED MORE THAN 150,000 MILES, THIS COVERAGE WILL LAST UNTIL JULY 31, 2005. IF EITHER FRONT COIL SPRING FRACTURES, DEALERS WILL REPLACE BOTH FRONT SPRINGS AT NO CHARGE TO THE OWNER. AN INTERIM NOTICE WAS SENT TO OWNERS ON AUGUST 2, 2004. PARTS ARE NOW AVAILABLE FOR THE 2000-2001 MY VEHICLES AND OWNERS WERE SENT A LETTER ON JANUARY 10, 2005, ADVISING THEM TO BRING IN THEIR VEHICLES FOR REPAIR PARTS ARE EXPECTED TO BE AVAILABLE FOR THE 1999 MY VEHICLES BY THE END OF FEBRUARY 2005 AND OWNERS OF THESE VEHICLES WILL BE NOTIFIED THEN. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.

Component: Seats (front assembly, power adjust)

Taurus model years: 2004 · about 24,277 vehicles in the whole campaign

The problem: CERTAIN PASSENGER VEHICLES EQUIPPED WITH POWER ADJUSTABLE SEATS MAY HAVE BEEN INADEQUATELY WELDED.

The risk: THE SEAT MAY NOT PERFORM AS INTENDED DURING A CRASH WHICH COULD INCREASE THE RISK OF INJURY.

The fix: DEALERS WILL REPLACE THE UPPER SUPPORT ASSEMBLY ON THE POWER SEATS. THE RECALL BEGAN ON JULY 20, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.

Component: Exterior lighting (brake lights, switch)

Taurus model years: 2000–2003 · about 938,789 vehicles in the whole campaign

The problem: CERTAIN PASSENGER VEHICLES ARE BEING RECALLED TO CORRECT A PROBLEM WITH A MALFUNCTIONING STOP LAMP SWITCH AND/OR ASSOCIATED WIRING. THIS MALFUNCTIONING COULD RENDER THE STOP LAMPS INOPERABLE OR CAUSE THEM TO STAY ON ALL THE TIME. THIS COULD CAUSE CONFUSION TO A FOLLOWING DRIVER, WHICH COULD LEAD TO A CRASH.

The risk: IN ADDITION, IF THE SWITCH AND/OR ASSOCIATED WIRING FAIL IN THE OPEN POSITION, THE BRAKE LIGHTS WILL NOT ACTUATE AND THE DRIVER WILL NOT BE ABLE TO SHIFT THE VEHICLE OUT OF "PARK" IF THEY FAIL IN THE CLOSED POSITION, THE BRAKE LIGHTS WILL REMAIN ON, WHICH WILL NOT ALLOW THE SPEED CONTROL TO BE ACTIVATED. THIS COULD ALSO CAUSE THE BATTERY TO DISCHARGE.

The fix: DEALERS WILL REMOVE THE STOP LAMP SWITCH AND ASSOCIATED WIRING ASSEMBLY AND INSTALL A NEWLY DESIGNED STOP LAMP SWITCH AND WIRE ASSEMBLY. OWNER NOTIFICATION IS EXPECTED TO BEGIN ON APRIL 5, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.

Component: Engine & cooling

Taurus model years: 2003 · about 399,926 vehicles in the whole campaign

The problem: ON CERTAIN VEHICLES, THE AIR FILTER PAPER IN THESE VEHICLES CAN SMOLDER OR BURN.

The risk: THIS CAN LEAD TO DAMAGE TO THE AIR INDUCTION SYSTEM ON THESE VEHICLES AND/OR AN UNDERHOOD FIRE.

The fix: DEALERS WILL REPLACE THE AIR FILTER ELEMENT. OWNER NOTIFICATION BEGAN ON MARCH 10, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.

Component: Visibility (windshield)

Taurus model years: 2002–2003 · about 67,894 vehicles in the whole campaign

The problem: CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, "WINDSHIELD MOUNTING." THE WINDSHIELDS MAY POTENTIALLY EXHIBIT INCREASED WIND NOISE, WATER LEAKAGE, AND SQUEAKS AND RATTLES.

The risk: POTENTIAL LOSS OF WINDSHIELD RETENTION MAY ALSO REDUCE OCCUPANT PROTECTION IN THE EVENT OF A CRASH.

The fix: DEALERS WILL REPLACE THESE WINDSHIELDS. OWNER NOTIFICATION BEGAN ON MARCH 31, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD/MERCURY AT 1-800-392-3673.

Component: Service brakes

Taurus model years: 2000–2002 · about 369,614 vehicles in the whole campaign

The problem: CERTAIN PASSENGER VEHICLES EQUIPPED WITH ADJUSTABLE PADELS ARE BEING RECALLED IN ORDER TO ADJUST THE BRAKE AND ACCELERATOR PEDALS TO A MINIMUM OF 50 MM OF LATERAL SEPARATION. SIMULTANEOUS APPLICATION OF BOTH THE BRAKE AND ACCELERATOR PEDALS COULD RESULT IN AN INCREASE IN ENGINE RPM.

The risk: THIS COULD RESULT IN A CUSTOMER EXPERIENCING AN "UNINTENDED VEHICLE SPEED INCREASE" OR A PERCEIVED "UNABLE TO STOP" CONDITION.

The fix: OWNERS WILL BE INSTRUCTED AS TO THE PROPER WAY TO SET THE POSITION OF THE PEDALS AND TO TAKE THEIR VEHICLES TO A DEALER TO HAVE THE SPACING BETWEEN THE BRAKE AND ACCELERATOR PEDALS MEASURED. IF THE SPACING IS FOUND TO BE LESS THAN 50 MM, THE DEALER WILL ADJUST THE PEDALS TO INCREASE THE DISTANCE BETWEEN THEM TO GREATER THAN 50 MM. OWNER NOTIFICATION BEGAN OCTOBER 28, 2002. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.

Component: Engine & cooling (cooling system, fan)

Taurus model years: 1995 · about 695,260 vehicles in the whole campaign

The problem: VEHICLE DESCRIPTION: TAURUS/SABLE VEHICLES EQUIPPED WITH 3.0L AND 3.8L ENGINES AND MUSTANG VEHICLES WITH 3.8L AND 5.0L ENGINES. IT IS POSSIBLE FOR THE ENGINE COOLING FAN BEARING TO SEIZE.

The risk: SHOULD THIS OCCUR, EXCESSIVE HEAT COULD BE GENERATED WHICH COULD MELT THE FAN MOTOR ELECTRICAL CONNECTOR. COMPONENTS INSIDE THE COOLING FAN MOTOR COULD IGNITE POTENTIALLY RESULTING IN AN UNDERHOOD FIRE.

The fix: DEALERS WILL INSPECT THE ENGINE COOLING FAN ASSEMBLY AND INSTALL A CIRCUIT BREAKER. IF THE COOLING FAN IS INOPERATIVE, THE FAN AND MOTOR ASSEMBLY WILL BE REPLACED. OWNER NOTIFICATION BEGAN DECEMBER 28, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.

Component: Engine & cooling (cooling system, fan)

Taurus model years: 1995 · about 695,260 vehicles in the whole campaign

The problem: THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1995 TAURUS/SABLE PASSENGER VEHICLES EQUIPPED WITH 3.0L AND 3.8L ENGINES AND 1995 FORD MUSTANG VEHICLES WITH 3.8L AND 5.0L ENGINES. IT IS POSSIBLE FOR THE ENGINE COOLING FAN BEARING TO SEIZE.

The risk: SHOULD THIS OCCUR, EXCESSIVE HEAT COULD BE GENERATED WHICH COULD MELT THE FAN MOTOR ELECTRICAL CONNECTOR. COMPONENTS INSIDE THE COOLING FAN MOTOR COULD IGNITE POTENTIALLY RESULTING IN AN UNDERHOOD FIRE.

The fix: DEALERS WILL REPLACE THE ENGINE COOLING FAN MOTOR ASSEMBLY AT NO CHARGE TO CONSUMERS. FORD IS EXTENDING THE LIMITED WARRANTY ON THE ENGINE COOLING FAN MOTOR TO A TOTAL OF 8 YEARS OR 100,000 MILES FROM THE WARRANTY START DATE, WHICHEVER OCCURS FIRST. THIS COVERAGE IS AUTOMATICALLY TRANSFERRED TO SUBSEQUENT OWNERS AT NO CHARGE. IF THE VEHICLE ALREADY HAS MORE THAN 100,000 MILES, THIS COVERAGE WILL LAST UNTIL JUNE 30, 2002. IF THE CONSUMER HAS PAID TO HAVE THIS SERVICE DONE BEFORE DECEMBER 2001, FORD IS OFFERING A REFUND. OWNERS CAN CONTACT FORD AT 1-866-436-7332, CONCERNING THIS PROGRAM.

Component: Visibility (windshield wiper/washer, motor)

Taurus model years: 2000–2001 · about 1,083,000 vehicles in the whole campaign

The problem: VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.

The risk: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.

The fix: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.

Component: Seat belts (front, buckle assembly)

Taurus model years: 2001 · about 4,567 vehicles in the whole campaign

The problem: VEHICLE DESCRIPTION: PASSENGER CARS. THE SEAT BELT BUCKLE TONGUE MAY NOT FULLY EJECT FROM THE BUCKLE ASSEMBLY WHEN THE RELEASE BUTTON IS PUSHED SLOWLY. THIS CONDITION COULD ALSO RESULT IN A PARTIAL LATCH OF THE TONGUE IN THE BUCKLE.

The risk: IN THE EVENT OF A VEHICLE CRASH, THE VEHICLE OCCUPANT MAY NOT BE PROPERLY RESTRAINED, POSSIBLY RESULTING IN PERSONAL INJURY OR DEATH.

The fix: DEALERS WILL REPLACE THE DRIVER AND RIGHT FRONT PASSENGER SEAT BELT BUCKLES. OWNER NOTIFICATION BEGAN MAY 4, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

Component: Exterior lighting (tail lights, switch)

Taurus model years: 2000–2001 · about 157,000 vehicles in the whole campaign

The problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS. IF THE GREASE FROM THE ADJUSTABLE PEDAL ASSEMBLY ENTERS THE STOP LAMP SWITCH, IT CAN CONTAMINATE THE CONTACTS LEADING TO CARBON BUILD UP, AND POTENTIALLY, A SHORT CIRCUIT.

The risk: A SHORT CIRCUIT COULD LEAD TO EITHER THE BRAKE LAMPS STAYING ON, OR TO A LOSS OF BRAKE LAMP FUNCTION, INCREASING THE RISK OF A CRASH.

The fix: DEALERS WILL REPLACE THE BRAKE LAMP SWITCH AND WIPE DOWN THE ADJUSTABLE PEDAL ASSEMBLY TO REMOVE EXCESS GREASE. OWNER NOTIFICATION BEGAN MARCH 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

Component: Exterior lighting (headlights, switch)

Taurus model years: 2000 · about 74,000 vehicles in the whole campaign

The problem: VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES. DUE TO THE USE OF INCORRECT MATERIAL BY A SUPPLIER, THE HEADLAMP SWITCH KNOB CAN FRACTURE AND SEPARATE FROM THE HEADLAMP SWITCH.

The risk: THIS WOULD CAUSE DIFFICULTY FOR THE DRIVER TO ACTIVATE THE HEADLAMPS, WHICH COULD AFFECT DRIVER VISIBILITY, INCREASING THE RISK OF A CRASH.

The fix: DEALERS WILL REPLACE THE HEADLAMP SWITCH KNOB. OWNER NOTIFICATION BEGAN APRIL 9, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

Component: Exterior lighting (back up lights)

Taurus model years: 2000–2001 · about 28,000 vehicles in the whole campaign

The problem: VEHICLE DESCRIPTION: PASSENGER SEDANS WITH FACTORY OR DEALER-INSTALLED DECK LID SPOILERS WITH LED CENTER HIGH MOUNTED STOP LAMPS (CHMSL). VEHICLES PRODUCED WITH SPOILERS WERE MANUFACTURED FROM MARCH 1 THROUGH OCTOBER 31, 2000; AND VEHICLES WITH SPOILERS INSTALLED BY DEALERS WERE MANUFACTURED FROM JANUARY 1 THOROUGH DECEMBER 30, 2000. WITH THE IGNITION SWITCH IN THE START OR RUN POSITIONS AND THE HAZARD WARNING LIGHTS OPERATING, THE CHMSL CAN ILLUMINATE (AT REDUCED INTENSITY) EVEN THOUGH THE SERVICE BRAKES HAVE NOT BEEN APPLIED. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." ALSO, IN SOME CASES THE VEHICLE BRAKE-SHIFT INTERLOCK WOULD NOT FUNCTION PROPERLY, ALLOWING THE SHIFT LEVER TO BE MOVED FROM PARK WITHOUT APPLYING THE BRAKE.

The risk: UNDER THE REQUIREMENTS OF THE STANDARD, THE CHMSL SHALL BE ACTIVATED ONLY UPON APPPLICATION OF THE SERVICE BRAKES. ALSO, THE VEHICLE COULD ROLL INCREASING THE RISK OF A CRASH, IF THE SHIFT LEVER CAN BE SHIFTED OUT OF PARK WITHOUT DEPRESSING THE BRAKE PEDAL.

The fix: DEALERS WILL INSTALL A JUMPER/RESISTOR ASSEMBLY AT THE SPOILER THAT PROVIDES AN ELECTRICAL RESISTOR TO GROUND AND CORRECTS THE CHMSL AND BRAKE-SHIFT INTERLOCK CONDITIONS. OWNER NOTIFICATION BEGAN MARCH 19, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

Component: Equipment (other, owners/service/other manual)

Taurus model years: 2001 · about 495,000 vehicles in the whole campaign

The problem: VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE AFFECTED EXPEDITION/NAVIGATOR OWNER GUIDES DO NOT IDENTIFY THE LOCATIONS OF SEATING POSITIONS EQUIPPED WITH TETHER ANCHORAGES, AND DO NOT PROVIDE INSTRUCTIONS FOR SECURING CHILD SEATS TO THESE TETHER ANCHORAGES. THE F150 SC OWNER GUIDES DO NOT PROVIDE THE PROCEDURE FOR SECURING CHILD SEATS TO THE TETHER ANCHORAGES. THE TAURUS/SABLE OWNER GUIDES DO NOT IDENTIFY THE CENTER REAR SEATING POSITION AS HAVING LATCH COMPATIBLE LOWER ANCHORAGES.

The risk: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.

The fix: OWNERS WILL BE PROVIDED WITH OWNER GUIDE INSERTS REVISED TO PROVIDE THE REQUIRED INFORMATION, AND INSTRUCTIONS FOR AFFIXING THESE INSERTS TO THEIR OWNER GUIDES. CUSTOMERS WILL ALSO BE ADVISED THAT IF THEY PREFER, THEIR DEALER WILL AFFIX THE INSERTS TO THEIR OWNER GUIDES.

Component: Equipment (other, labels)

Taurus model years: 2000 · about 167,000 vehicles in the whole campaign

The problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE "VEHICLE CAPACITY WEIGHT" AND "DESIGNATED SEATING CAPACITY" INFORMATION WAS NOT PRINTED ON THE SAFETY CERTIFICATION LABELS AFFIXED TO THESE VEHICLES. ON AFFECTED SABLE SEDAN VEHICLES, THE "VEHICLES CAPACITY WEIGHT" (AND ALSO THE LUGGAGE LOAD) INFORMATION PRINTED ON THIS LABEL IS INCORRECT - SABLE WAGON LUGGAGE LOAD WAS INCORRECTLY USED FOR THE SABLE SEDAN. THESE VEHICLES DO NOT COMPLY WITH THE LABEL REQUIREMENTS OF FMVSS NO. 110, "TIRE SELECTION AND RIMS."

The risk: EXCESSIVE LOADING CAN CAUSE TIRE AND VEHICLE DAMAGE THAT COULD RESULT IN A CRASH.

The fix: OWNERS WILL BE PROVIDED WITH A SUPPLEMENTAL LABEL WITH THE CORRECT INFORMATION, ALONG WITH INSTRUCTIONS FOR AFFIXING THE LABEL ADJACENT TO THE VEHICLE CERTIFICATION LABEL. OWNER NOTIFICATION BEGAN OCTOBER 20, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

Component: Seat belts (front, anchorage)

Taurus model years: 2001 · about 5,961 vehicles in the whole campaign

The problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE CHILD SAFETY SEAT ANCHOR LATCH (ISO-FIX ANCHOR) FASTENERS DO NOT HAVE ADEQUATE RESIDUAL TORQUE. THE ANCHORS ARE SECURED TO THE FLOOR PAN WITH A REINFORCEMENT PLATE THAT HAS TWO STUDS THAT EXTEND UPWARD THROUGH THE FLOOR PAN AND THE ISO-FIX ANCHOR. THE SEALER ON THE FLOOR PAN COULD CAUSE A SOFT JOINT AND, EVEN IF THE NUTS ARE PROPERLY TORQUED, ROAD VIBRATIONS COULD CAUSE THE NUT TO WORK ITS WAY COMPLETELY OFF THE STUD.

The risk: THE ANCHOR MAY NOT HOLD THE CHILD SAFETY SEAT IN POSITION DURING AN ACCIDENT, INCREASING THE RISK OF INJURY TO THE OCCUPANT OF THE CHILD SAFETY SEAT.

The fix: DEALERS WILL REMOVE AND RE-INSTALL THE BRACKET NUT USING A TORQUE RETENTION MATERIAL (RED LOCTITE). OWNER NOTIFICATION BEGAN SEPTEMBER 11, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

Component: Seat belts (front, anchorage)

Taurus model years: 1999 · about 25,306 vehicles in the whole campaign

The problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SEAT BELT RETRACTOR MAY HAVE A PIN SHAFT IN THE SWITCHABLE ELR/ALR MECHANISM THAT IS INCORRECTLY FORMED. IN SOME CIRCUMSTANCES, THE SWITCHING MECHANISM COULD BECOME NONFUNCTIONAL, PREVENTING THE SEAT BELT WEBBING FROM BEING EXTRACTED FROM THE RETRACTOR. IT IS ALSO POSSIBLE THAT MALFUNCTION OF THE MECHANISM COULD PREVENT THE BELT FROM BEING SWITCHED INTO THE ALR MODE. THE ELR MECHANISM IS NOT AFFECTED BY THIS CONDITION.

The risk: IF THE MECHANISM MALFUNCTIONS AND DOES NOT ALLOW THE WEBBING TO BE EXTRACTED, THE LAP AND SHOULDER BELT COULD NOT BE WORN BY A VEHICLE OCCUPANT. IN THE EVENT THAT THE MECHANISM DOES NOT ALLOW THE ALR MODE TO BE ENGAGED, THE OPERATOR MAY BE UNABLE TO PROPERLY INSTALL A CHILD SEAT IN THAT SEATING POSITION.

The fix: DEALERS WILL INSPECT THE LAP AND SHOULDER BELT ASSEMBLIES. ASSEMBLIES WITH JULIAN DATE CODES OF 200 THROUGH 223 ARE SUSPECT AND WILL BE REPLACED.

Component: Structure (frame and members)

Taurus model years: 1995 · about 2,697,000 vehicles in the whole campaign

The problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.

The risk: IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.

The fix: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.

Component: Powertrain / transmission (automatic transmission, cooling unit and lines)

Taurus model years: 1999 · about 1,800 vehicles in the whole campaign

The problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUPPED WITH THE "CALIFORNIA" EMISSIONS PACKAGE. AN INCORRECT TRANSMISSION OIL COOLER LINE WAS INSTALLED. THE LINE CONTACTS THE ANTI-LOCK BRAKING SYSTEM MODULE SUPPORT BRACKET AND OVER TIME, CAN WEAR AND DEVELOP A LEAK.

The risk: TRANSMISSION FLUID LEAKAGE ONTO THE EXHAUST MANIFOLD OR CATALYTIC CONVERTER CAN RESULT IN A FIRE.

The fix: DEALERS WILL INSTALL THE APPROPRIATE TRANSMISSION OIL COOLER LINE.

Component: Speed control / throttle

Taurus model years: 1999 · about 6,000 vehicles in the whole campaign

The problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DASH INSULATOR RETAINER CLIP WAS NOT FULLY ASSEMBLED TO THE ACCELERATOR CABLE DASH FITTING. THE CLIP CAN DISENGAGE FROM THE ACCELERATOR CABLE AND FALL INTO THE ACCELERATOR PEDAL ARM PIVOT AREA.

The risk: IF THIS CONDITION OCCURS, THE ENGINE MAY NOT FULLY RETURN TO IDLE. ALSO, THE INSULATOR MAY NOT STAY IN THE INTENDED LOCATION AND COULD INTERFERE WITH THE ACCELERATOR CABLE.

The fix: DEALERS WILL INSPECT THESE VEHICLES TO ENSURE PROPER INSTALLATION OF THE ACCELERATOR CABLE CLIP, AND RE-INSTALL IF NEEDED.

Component: Seat belts (front, anchorage)

Taurus model years: 1998–1999 · about 7,000 vehicles in the whole campaign

The problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUAL SEAT TRACKS. THE FRONT SEAT BELT BUCKLE ATTACHING STUD MAY HAVE BEEN IMPROPERLY HEAT TREATED. THIS HEAT TREATMENT MAY HAVE RESULTED IN CRACKS DEVELOPING IN THE STUD.

The risk: IF THE STUD IS CRACKED, IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.

The fix: DEALERS WILL REPLACE THE SEAT BELT BUCKLE MOUNTING BRACKET AND STUD ASSEMBLY.

Component: Fuel system

Taurus model years: 1996 · about 400 vehicles in the whole campaign

The problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES PREVIOUSLY SERVICED UNDER FORD SERVICE BULLETIN 97-17-9 FROM AUGUST 1997 THROUGH DECEMBER 1997. THESE VEHICLES WERE INADVERTENLY EQUIPPED WITH AN 18-GALLON FUEL TANK RATHER THAN THE 16-GALLON AS SPECIFIED. THE 18-GALLON TANK HAS A SECOND VALVE LOCATION WHERE A SHIPPING PLUG SHOULD BE INSTALLED.

The risk: IF THIS SHIPPING PLUG IS DISPLACED, FUEL LEAKAGE CAN RESULT. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD POTENTIALLY RESULT IN A FIRE.

The fix: DEALERS WILL INSTALL THE CORRECT FUEL TANK.

Component: Exterior lighting (headlights)

Taurus model years: 1997–1998 · about 571,800 vehicles in the whole campaign

The problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TEXT AND/OR GRAPHICS FOR THE VEHICLE HEADLAMP AIMING INSTRUCTIONS PROVIDED IN THE OWNER GUIDES ARE NOT SUFFICIENTLY CLEAR. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

The risk: IF THE HEADLAMP ASSEMBLIES ARE REPLACED, CUSTOMERS MAY BE CONFUSED BY THE AIMING INSTRUCTIONS PROVIDED IN THE OWNER GUIDES CAUSING THE HEADLAMPS TO BE IMPROPERLY AIMED.

The fix: OWNER GUIDES CONTAINING REVISED AIMING INSTRUCTIONS WILL BE MAILED TO OWNERS OF THESE VEHICLES.

Component: Powertrain / transmission (automatic transmission)

Taurus model years: 1997 · about 100,000 vehicles in the whole campaign

The problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AX4S AUTOMATIC TRANSAXLES. THE LOW/INTERMEDIATE SERVO COVER CAN SEPARATE FROM THE TRANSAXLE WHILE THE VEHICLE IS BEING DRIVEN. IF THIS OCCURS, TRANSMISSION FLUID WILL LEAK CONTACTING THE CATALYTIC CONVERTER.

The risk: THE CATALYTIC CONVERTER TEMPERATURE MAY BE HOT ENOUGH TO IGNITE THE TRANSMISSION FLUID AND CAUSE A VEHICLE FIRE.

The fix: DEALERS WILL INSPECT THE TRANSMISSION AND REPLACE THESE SERVO COVERS.

Component: Speed control / throttle

Taurus model years: 1995 · about 212,700 vehicles in the whole campaign

The problem: VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 3.8L ENGINES AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WATER CAN ACCUMULATE WITHIN THE SPEED CONTROL CABLE CONDUIT. IF ENOUGH WATER ACCUMULATES, IT COULD FREEZE WITHIN A LOW AREA OF THE CABLE ROUTING WHEN EXPOSED TO A LONG TERM COLD SOAK AT TEMPERATURES AT LEAST SEVERAL DEGREES BELOW FREEZING.

The risk: DRIVER CONTROL OF VEHICLE SPEED USING THE SPEED CONTROL SYSTEM OR THE ACCELERATOR CONTROL SYSTEM WOULD BE DIMINISHED INCREASING THE RISK OF A VEHICLE CRASH.

The fix: DEALERS WILL ADD A BOOT TO THE SPEED CONTROL CABLE.

Component: Engine & cooling (cooling system, fan)

Taurus model years: 1995 · about 75,200 vehicles in the whole campaign

The problem: THESE VEHICLES ARE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, IOWA, MINNESOTA, NEBRASKA, NORTH DAKOTA, AND SOUTH DAKOTA. THE VEHICLES INVOLVED ARE 1992-1994 TEMPO/TOPAZ VEHICLES WITH 3.0L ENGINES; 1994 TEMPO/TOPAZ WITH 2.3L ENGINES; 1992-1995 TAURUS/SABLE WITH 3.8L ENGINES; 1994-1995 TAURUS/SABLE WITH 3.0L ENGINES AND 1992-1994 LINCOLN CONTINENTAL VEHICLES WITH 3.8L ENGINES. DURING HIGH WINDS, HEAVY, BLOWING AND DRIFTING SNOW, AND LOW TEMPERATURES, THE ENGINE COOLING FAN CAN BECOME BLOCKED OR FROZEN WITH SNOW. THE FAN MOTOR MAY NOT ROTATE AND COULD OVERHEAT.

The risk: THIS CONDITION CAN CAUSE SMOKE OR FLAMES FROM THE FAN AND/OR SHROUD, THE FAN ELECTRICAL WIRING, OR THE FAN MOTOR RESULTING IN A VEHICLE FIRE.

The fix: DEALERS WILL INSTALL AN ELECTRICAL JUMPER HARNESS CONTAINING AN AUTOMATIC RESETTING CIRCUIT BREAKER TO PROTECT THE FAN MOTOR LOW SPEED CIRCUITRY FROM OVERHEATING.

Component: Powertrain / transmission (automatic transmission)

Taurus model years: 1996 · about 340,000 vehicles in the whole campaign

The problem: THE AUTOMATIC TRANSMISSION PARK PAWL SHAFT MAY NOT BE FREE TO ROTATE AS INTENDED. IF THE PARK PAWL SHAFT DOES NOT ROTATE, IT WOULD PREVENT THE PARK PAWL FROM ENGAGING THE PARK GEAR WHEN THE SHIFT LEVER IS IN THE PARK POSITION.

The risk: THIS CONDITION COULD RESULT IN THE VEHICLE ROLLING AS IF IN NEUTRAL WITH THE SHIFT LEVER IN THE PARK POSITION.

The fix: DEALERS WILL INSPECT THE PARK PAWL SHAFT ROTATION AND THOSE SHAFTS WITH RESTRICTED ROTATION WILL BE REPLACED WITH A SHORTER SHAFT THAT WILL NOT RESTRICT ROTATION.

Component: Powertrain / transmission (automatic transmission, gear position indication (prndl))

Taurus model years: 1996–1997 · about 40,000 vehicles in the whole campaign

The problem: THE PARK PAWL ABUTMENT BRACKET HAS A SHARP EDGE WHICH CAN CAUSE THE PARKING PAWL TO HANG UP AND NOT ENGAGE THE PARK GEAR. THIS WOULD ALLOW THE VEHICLE TO MOVE EVEN THOUGH THE GEAR SHIFT INDICATOR SHOWS THAT THE VEHICLE IS IN PARK.

The risk: UNINTENDED AND UNEXPECTED VEHICLE MOVEMENT CAN RESULT IN PERSONAL INJURY AND PROPERTY DAMAGE.

The fix: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE PARK PAWL ABUTMENT BRACKET.

Component: Fuel system

Taurus model years: 1996 · about 4,700 vehicles in the whole campaign

The problem: THE FUEL PRESSURE REGULATOR LOCATED ON THE FUEL RAIL IN THE ENGINE COMPARTMENT HAS A VACUUM DIAPHRAGM THAT WAS DAMAGED DURING MANUFACTURE OF THE REGULATOR.

The risk: IF THE DIAPHRAGM TEARS OR RUPTURES, LIQUID FUEL COULD ENTER THE INTAKE MANIFOLD PLENUM THROUGH THE VACUUM LINE RESULTING IN EITHER RELEASE OF FUEL FROM THE AIR CLEANER ASSEMBLY OR THE EXHAUST SYSTEM. FUEL RELEASE IN THE PRESENCE OF AN IGNITION SOURCE COULD POTENTIALLY RESULT IN A FIRE.

The fix: DEALERS WILL INSPECT THE FUEL PRESSURE REGULATOR. THOSE REGULATORS PRODUCED DURING THE SUSPECT TIME PERIOD WILL BE REPLACED.

Component: Powertrain / transmission (automatic transmission)

Taurus model years: 1996 · about 100,000 vehicles in the whole campaign

The problem: THE PARK PAWL SHAFT WAS IMPROPERLY POSITIONED WHEN THE ROLL PIN THAT RETAINS IT WAS INSTALLED DURING TRANSMISSION ASSEMBLY. IF THE SHAFT WAS NOT PROPERLY POSITIONED, THE ROLL PIN MAY NOT HAVE LINED UP WITH THE GROOVE IN THE SHAFT AND HAVE BEEN CRUSHED AT ASSEMBLY. ALSO, A BURR COULD HAVE BEEN RAISED ON THE SHAFT.

The risk: THIS COULD RESULT IN THE PARK PAWL OCCASIONALLY NOT ENGAGING WHEN THE TRANSMISSION SELECTOR LEVER IS PLACED IN THE PARK POSITION. THIS COULD RESULT IN THE VEHICLE ROLLING AS IF IN NEUTRAL IF THE VEHICLE OPERATOR DOES NOT APPLY THE PARKING BRAKE.

The fix: DEALERS WILL INSPECT THE PARK PAWL SHAFT ROLL PIN. IF THE ROLL PIN IS DAMAGED, BOTH THE ROLL PIN AND THE PARK PAWL SHAFT WILL BE REPLACED. IN ADDITION, OWNERS WILL BE REMINDED TO FULLY APPLY THE PARKING BRAKE, IN ADDITION TO PLACING THE TRANSMISSION IN PARK.

Component: Service brakes

Taurus model years: 1996 · about 76,500 vehicles in the whole campaign

The problem: THE BRAKE SYSTEM FLUID LEVEL INDICATOR LAMP SWITCH CAN MALFUNCTION. THIS DOES NOT COMPLY WITH FMVSS NO. 105, "HYDRAULIC BRAKE SYSTEMS."

The risk: CONSEQUENCE OF NON-COMPLIANCE: IF THE SWITCH MALFUNTIONS, THE BRAKE SYSTEM WARNING LAMP WILL EITHER REMAIN ILLUMINATED CONTINUOUSLY OR FAIL TO LIGHT AS INTENDED WHEN THE FLUID LEVEL FALLS TO A CERTAIN LEVEL. IN EITHER CASE, THE VEHICLE OPERATOR WOULD NOT BE WARNED OF A LOW BRAKE FLUID LEVEL CONDITION.

The fix: DEALERS WILL REPLACE THE BRAKE SYSTEM FLUID LEVEL INDICATOR LAMP SWITCHES.

Component: Service brakes

Taurus model years: 1995 · about 1,500 vehicles in the whole campaign

The problem: THE RETAINER CLIP WHICH HOLDS THE MASTER CYLINDER PUSH ROD TO THE BRAKE PEDAL ARM IS MISSING OR NOT COMPLETELY INSTALLED. THE PUSH ROD CAN SEPARATE FROM THE BRAKE PEDAL ARM.

The risk: THIS CAN RESULT IN LOSS OF BRAKING ABILITY AND AN ACCIDENT.

The fix: DEALERS WILL INSPECT AND, IF NECESSARY, INSTALL THE RETAINER CLIP.