NHTSA Recall Check

2002 Toyota Highlander Recalls

NHTSA reports 2 open safety recalls for the 2002 Toyota Highlander. All recall repairs are free at any authorized Toyota dealer, regardless of mileage or ownership.

Open Recalls for the 2002 Toyota Highlander

04V181000Reported 15/04/2004

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Summary

CERTAIN SPORT UTILITY VEHICLES HAVE A CHILD PROTECTION LOCK (CPL) SYSTEM ON BOTH OF THE REAR SIDE DOORS. WHEN AN OPERATOR OF THE VEHICLE CLOSES THE DOOR VERY HARD WITH THE CPL LEVER SET TO THE LOCK POSITION, THERE IS A POSSIBILITY THAT THE LEVER MAY CONTACT THE BODY PANEL, CAUSING THE CPL LEVER TO MOVE INTO THE UNLOCK POSITION.

Consequence

THIS CONDITION COULD ALLOW THE DOOR TO BE OPENED WITH THE INSIDE WHILE THE OPERATOR BELIEVES THAT THE CPL WAS ACTIVATED. IF THE DOOR WERE OPENED FROM THE INSIDE WHILE THE VEHICLE WAS IN MOTION, AN OCCUPANT COULD FALL OUT AND BE INJURED.

Remedy

DEALERS WILL SHORTEN THE CPL LEVER. OWNER NOTIFICATION BEGAN MAY 7, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.

Source: NHTSA campaign 04V181000 via nhtsa.gov/recalls

02V208000Reported 30/07/2002

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING

Summary

ON SPORT UTILITY VEHICLES, THERE IS A BREATHER HOSE THAT ATTACHES TO THE NOZZLE OF THE ON-BOARD REFUELING VAPOR RECOVERY (ORVR) VALVE, WHICH IS LOCATED ON THE TOPSIDE OF THE FUEL TANK. THE BREATHER HOSE IS ATTACHED WITH A CLAMP, WHOSE "TABS" FACE IN THE UPWARD DIRECTION. WHEN THE VEHICLE WAS CRASHED UNDER THE NEW CAR ASSESSMENT PROGRAM (NCAP) TEST (I.E., 35 MPH FRONTAL BARRIER CRASH), THE CLAMP "TABS" CONTACTED THE UNDERSIDE OF THE BODY DUE TO MOVEMENT OF THE FUEL TANK, CAUSING THE NOZZLE TO BREAK.

Consequence

IN THE WORST CASE, NOZZLE BREAKAGE COULD RESULT IN FUEL LEAKAGE IF THE VEHICLE ROLLS-OVER AFTER A HIGH SPEED FRONTAL CRASH.

Remedy

DEALERS WILL ROTATE THE SPECIFIED CLAMP. OWNER NOTIFICATION BEGAN SEPTEMBER 23, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.

Source: NHTSA campaign 02V208000 via nhtsa.gov/recalls

See 2002 Toyota Highlander prices →

Verified buyer transactions, not estimates.

Toyota VIN decoder →

Decode any Toyota VIN free.

How to Get a Recall Repaired

  1. Confirm the recall applies to your specific Toyota Highlander by checking the VIN above.
  2. Note the NHTSA campaign number from the recall details.
  3. Call any authorized Toyota dealer and reference the campaign number.
  4. Schedule the free repair. By federal law, the dealer must perform the recall remedy at no cost regardless of vehicle age or owner.
  5. Bring the vehicle to the appointment. Most recall repairs take 1-3 hours; some require parts to be ordered first.

Buying a 2002 Toyota Highlander?

See what real buyers paid for this exact year and model on CarWhere — verified from actual deal sheets, not dealer ads.

Browse Toyota Highlander Prices